Het batterijprobleem.... oplossen?

De specifiek op motorrijders gerichte 5 inch navigatiesystemen van Garmin, introductie 2014
Gebruikersavatar
Mgent
WayPoint relatie
WayPoint relatie
Berichten: 2649
Lid geworden op: 28 aug 2007 09:44
Locatie: Adinkerke

Het batterijprobleem.... oplossen?

Bericht door Mgent »

Zowat iedereen hier heeft er mee te maken, de batterij van je 59x gaat al snel weer zonder energie zitten.
Gisteren las ik op het net een issu, waar met wat friemelwerk, je die batterijduur opschroeft naar meer dan 3 of 4 uur.

Hieronder de link :
http://www.zumoforums.com/index.php?topic=19321.0
Zumo XT, iPhone 13 Pro Max, Shubert SRC M1+ SCM1 , BaseCamp 4.8.12, CN Europe NTU 2023.20, Onroute motor 5.15 Europa, tomtom Vio.

manus
WayPoint relatie
WayPoint relatie
Berichten: 498
Lid geworden op: 11 jun 2005 19:13

Re: Het batterijprobleem.... oplossen?

Bericht door manus »

De link werkt niet zonder inloggen.
Garmins wegen zijn ondoorgrondelijk.

Gebruikersavatar
QuattroFrits
WayPoint relatie
WayPoint relatie
Berichten: 2935
Lid geworden op: 13 jan 2008 16:59
Locatie: Hulsberg
Contacteer:

Re: Het batterijprobleem.... oplossen?

Bericht door QuattroFrits »

Had ik ook al last van.
Met een GPS geen stress en zonder GPS vergaat de wereld ook niet.
Virb XE + Zumo XT + Nuvi 2599 LMT-D + Schuberth C4 Pro met SC1A + Dashcam 67W.

Gebruikersavatar
Mgent
WayPoint relatie
WayPoint relatie
Berichten: 2649
Lid geworden op: 28 aug 2007 09:44
Locatie: Adinkerke

Re: Het batterijprobleem.... oplossen?

Bericht door Mgent »

Hieronder de tekst en link naar foto's:

So I took my zumo 590 out of the cupboard to check my new wiring on my mount all works fine

Upon removing the zumo from the mount the zumo turned off which is pretty normal for these after been stored and battery issues with them etc

So I thought I would just give it a good charge even though I know it will be flat again when I come to use it!

The unit just kept turning straight off after pulling the power even though it was showing as charged! and every time I turned it on it would just shut down as if the batter was flat! even after been left for 4 or 5 hours on charge!

I have contacted Garmin again but I thought to myself enough is enough and I will order a new battery tomorrow (monday). So I thought sod it I pulled the battery and removed the connector pins one by one and bent them to give them a better connection to the unit! I thought why not as I am only going to get a battery anyway!

plugged it in turned it on and hey presto working zumo with 100% battery and just slowly creeping down while it is on!

I am going to see how it performs over the next few days of charging and draining but to me it looks as if the battery has always had a bad connection as its never been any good

Maybe its the solution to the battery issues!

Click images to enlarge.

If you look at the connector on the battery you will see 5 small tabs.You need to lift these and pull the wire and pin out of the connector block. Be careful as they are a little delicate you can see that one of mine is a bit bent as I was a bit rough.


Once removed you need to bend the pin very slightly in the direction shown here. Be careful not to over do it and keep the pin straight as they easily go off centre.


Ensure the tab is straight and pushed back down on the connector block then insert the pin and wire back in to its slot ensuring it is fully home give it a little tug to make sure it is.

You could also probably go in from the back of the connector block with a pin and bend the connector pin but I removed them as I also wanted to give them a clean

Foto's
http://s141.photobucket.com/user/stu_m_ ... 7.jpg.html
Zumo XT, iPhone 13 Pro Max, Shubert SRC M1+ SCM1 , BaseCamp 4.8.12, CN Europe NTU 2023.20, Onroute motor 5.15 Europa, tomtom Vio.

Gebruikersavatar
Mgent
WayPoint relatie
WayPoint relatie
Berichten: 2649
Lid geworden op: 28 aug 2007 09:44
Locatie: Adinkerke

Re: Het batterijprobleem.... oplossen?

Bericht door Mgent »

En een reactie hierop:

Thanks for sharing Stu - Best FIX yet!

Your fix increased the battery life on my 595 from less than 30 minutes to 4 hours & 11 minutes! The best battery life I ever got with the 595 when it was new was about an hour. Bear in mind that all of my battery tests were done with zero backlight, Bluetooth off & GPS simulator on.

To do your fix, I used a jewelers screwdriver in one hand to push the individual terminals, used the other hand to hold the battery plug & used my knees to hold the biggest magnifying glass I could find. I studied the plug, socket & terminals for about 20 minutes before trying to push each individual terminal. I had a hell of a time seeing the battery terminals let alone bending them, so I'm not sure I could describe more detail about what I pushed. My initial try must have gone too far because I couldn't fit the male battery plug in the female Zumo socket. So,... I pushed the terminals back the other way a few times 'til the plug would fit with a slight amount of force.

This poor battery connection is probably why my two previous 590s also had such poor battery life. In addition, the bad battery connection may explain why my previous 590s randomly rebooted themselves. After a few months, my initial 590 started rebooting itself a few times a week. Over time, this rebooting increased in frequency - sometimes as often 10 times in 10 minutes.
Zumo XT, iPhone 13 Pro Max, Shubert SRC M1+ SCM1 , BaseCamp 4.8.12, CN Europe NTU 2023.20, Onroute motor 5.15 Europa, tomtom Vio.

Dingeman
WayPoint relatie
WayPoint relatie
Berichten: 602
Lid geworden op: 25 nov 2005 16:14

Re: Het batterijprobleem.... oplossen?

Bericht door Dingeman »

Dit is toch een Nederlandstalig forum.

Gebruikersavatar
HaWee
Onafhankelijk GPS-specialist
Onafhankelijk GPS-specialist
Berichten: 22860
Lid geworden op: 28 jul 2008 16:24
Locatie: Eindhoven

Re: Het batterijprobleem.... oplossen?

Bericht door HaWee »

Ja,
maar deze oplossing staat op een engelstalig forum :wink:
de meeste gebruikers kunnen het wel lezen, en anders gewoon even naar https://translate.google.nl
geeft best leuk resultaat :roll:
"Always Look on the Bright Side of Life"

manus
WayPoint relatie
WayPoint relatie
Berichten: 498
Lid geworden op: 11 jun 2005 19:13

Re: Het batterijprobleem.... oplossen?

Bericht door manus »

Lezen is 1.
Zelf repareren is 2.
Hoe is het dan met de garantie?
Als dit de oplossing is moet dit door Garmin opgepakt worden, toch?
Garmins wegen zijn ondoorgrondelijk.

Gebruikersavatar
HaWee
Onafhankelijk GPS-specialist
Onafhankelijk GPS-specialist
Berichten: 22860
Lid geworden op: 28 jul 2008 16:24
Locatie: Eindhoven

Re: Het batterijprobleem.... oplossen?

Bericht door HaWee »

ik verwacht dat het wel meevalt qua garantie

maar je zou even contact op kunnen nemen met de TD in Notter, die zijn garmin certified
"Always Look on the Bright Side of Life"

Dingeman
WayPoint relatie
WayPoint relatie
Berichten: 602
Lid geworden op: 25 nov 2005 16:14

Re: Het batterijprobleem.... oplossen?

Bericht door Dingeman »

HaWee schreef:Ja,
maar deze oplossing staat op een engelstalig forum :wink:
de meeste gebruikers kunnen het wel lezen, en anders gewoon even naar https://translate.google.nl
geeft best leuk resultaat :roll:
Heb ik dus even gedaan. Als je met deze vertaling(en) aan je Zumo wilt gaan "sleutelen", dan kun je deze net zo goed meteen in de vuilnisbak gooien.

Maar misschien gaat WayPoint wel met een deskundig advies komen om iets te doen of niet te doen.

Gebruikersavatar
Mgent
WayPoint relatie
WayPoint relatie
Berichten: 2649
Lid geworden op: 28 aug 2007 09:44
Locatie: Adinkerke

Re: Het batterijprobleem.... oplossen?

Bericht door Mgent »

Ik heb het dan maar zelf even getest. Een batterij genomen, welke steeds vrij snel plat was, en ondertussen al ruim acht maand in de schuif lag.
Heb de pinnetjes er niet uit gehaald, maar met een fijne naald deze allemaal een beetje naar voor geduwd.
Batterij ingeplugd, toestel aan en een lange route laten lopen in simulatie. Scherm stond op 100%.
Na ruim anderhalf uur begon het scherm te dimmen.Maar plat was het toestel nog niet.
Binnenkort de test nog eens doen met een vers geladen.
Zumo XT, iPhone 13 Pro Max, Shubert SRC M1+ SCM1 , BaseCamp 4.8.12, CN Europe NTU 2023.20, Onroute motor 5.15 Europa, tomtom Vio.

Gebruikersavatar
FM
WayPoint relatie
WayPoint relatie
Berichten: 5006
Lid geworden op: 30 mei 2005 20:49
Locatie: Holsbeek

Re: Het batterijprobleem.... oplossen?

Bericht door FM »

Met andere woorden, ook bij jou heeft het dus geholpen??

Dan ga ik ook eens wat frutselen. Want die korte batterijduur is toch een echt minpunt.
Zumo XT, KTM 790 Adventure, SRC op Schubert C3 Pro, Edge Touring, Edge Explorer 2

manus
WayPoint relatie
WayPoint relatie
Berichten: 498
Lid geworden op: 11 jun 2005 19:13

Re: Het batterijprobleem.... oplossen?

Bericht door manus »

Contactspray een oplossing misschien?
Garmins wegen zijn ondoorgrondelijk.

Hervelt
WayPoint relatie
WayPoint relatie
Berichten: 481
Lid geworden op: 22 mei 2015 18:30
Locatie: Breda

Re: Het batterijprobleem.... oplossen?

Bericht door Hervelt »

Als er te weinig veerdruk is zo contactspray ook niet veel helpen,
Dat met die naald herken ik wel. Zo deed ik het ook bij oude gsm connectoren of de carkit contacten

Gebruikersavatar
Mgent
WayPoint relatie
WayPoint relatie
Berichten: 2649
Lid geworden op: 28 aug 2007 09:44
Locatie: Adinkerke

Re: Het batterijprobleem.... oplossen?

Bericht door Mgent »

En kijk, zelfs MrGPS heeft nu van mijn tip een filmpje gemaakt op Fb.
https://www.facebook.com/mrgpsnl/?fref=ts
Zumo XT, iPhone 13 Pro Max, Shubert SRC M1+ SCM1 , BaseCamp 4.8.12, CN Europe NTU 2023.20, Onroute motor 5.15 Europa, tomtom Vio.

Plaats reactie

Terug naar “Garmin Zumo 590”